Optimization and Performance Test of Oil Spill Dispersant  at Bioremediation of Contaminated Soil with Heavy Oil  by Bioslurry Technique

Muhammad Abdul Aziz; Mohamad Yani; Agung Dhamar Syakti

doi:10.5400/jts.2020.v25i1.1-10

Optimization and Performance Test of Oil Spill Dispersant at Bioremediation of Contaminated Soil with Heavy Oil by Bioslurry Technique

Muhammad Abdul Aziz, Mohamad Yani, Agung Dhamar Syakti

Abstract

Petroleum industry activities produce waste such as petroleum hydrocarbons which damage to the soil environment due to changes in soil physical, chemical and biological properties. Oil Spill Dispersant (OSD) is a product that can break down waste of oil into small parts so that it can be dispersed naturally. Laboratory experiments aimed to find out optimize and performance test of OSD in the process of bioremediation with using bio-slurry technique on contaminated soil with heavy oil was carried out at Laboratory of Surfactant and Bio-energy Research Center (SBRC), Research and Community Service Institute of Bogor Agricultural University on January - August 2018 using contaminated soil with heavy oil. The experiment used Response Surface Method (RSM) with two factors, namely the incubation time factor (X1) and the Dispersant to oil ratio (DOR) (X2). The observed variables were soil Total Petroleum Hydrocarbons (TPH), pH, total microbes, and Chemical Oxygen Demand (COD) at soil solution. The results showed that the treatment of incubation time and its combination with DOR significantly reduced soil TPH, increased soil acidity, and increased soil total B. megaterium, but did not significantly affect on COD in soil solutions. Optimization of OSD with RSM showed that the higher DOR of OSD and the longer the incubation time, the higher also the rate of biodegradation of TPH. The optimum conditions were reached at DOR of 1.16:1 and incubation time of 7 days which were able to degrade soil TPH of 54.30%. The optimum conditions of soil pH (8.825) was reached at DOR of 1:1 and incubation time of 5 days, as well as the optimum conditions of B. megaterium (8.35 log CFU g-1) was reached at DOR of 0.86:1 and incubation time of 7 days. Oil spill dispersant (OSD) increased COD in soil solution in both uncontaminated and contaminated soils with heavy oil.

Keywords

Bioremediation; bioslurry; contaminated soil; heavy oil; oil spill dispersant

Full Text:

PDF

References

Adlina S. 2016. Kinerja OSD (Oil Spill Dispersant) dari Surfakktan Minyak Sawit dengan Penambahan Pseudomonas aeruginosa IPBCC.b11662 Untuk Bioremediasi Tanah Tercemar Hidrokarbon Minyak Bumi [Tesis]. Institut Pertanian Bogor. Bogor (ID). (in Indonesian).

Adlina S, M Yani and E Hambali. 2017. Oil spill dispersant (OSD) formulation of palm oil base surfactant for bioremediation of soil contaminated hydrocarbons. Chem Process Eng Res 53: 1-12.

APHA [American Public Health Association]. 1992. Standard Methods for the Examination of Water and 18th Wastewater. edition. Washington DC: APHA, AWWA& WEF.

Banerji SK. 1997. Bioreactor for Soil and Sediment Remediation. In: RK Bajpai and ME Zappi (eds). Bioremediation of Surface and Subsurface Contamination. New York. The New York Academy of Sciences.

Benedek T, B Vajna, A Tancsics, K Marialigeti, S Lanyi and I Mathe. 2013. Remarkable impact of PAHs and TPHs on the richness and diversity of bacterial species in surface soils exposed to long-term hydrocarbon pollution. J. Microbiol Biotechnol 29:1989-2002.

Budianto H. 2008. Perbaikan Lahan Terkontaminasi Minyak Bumi Secara Bioremediasi. Jakarta: Indonesia Environment Consultant. (in Indonesian).

Center Bureau of Statistics. 2016. BP Statistical Review of World Energy. London (GB): BP statistical

Chanif I, H Erliza and M Yani. 2017. Kinerja oil spill dispersant dalam proses bioremediasi tanah tercemar minyak bumi (studi kasus tanah tercemar minyak bumi lapangan XYZ). J Tek Industri Pertanian 27: 336-344. (in Indonesian).

Charlena, Z Alim Mas’ud, A Syahreza and AS Purwadayu. 2009. Profil kelarutan limbah minyak bumi dalam air akibat pengaruh surfaktan nonionik dan laju pengadukan. Chem Prog 2: 69-78. (in Indonesian).

Charlena. 2010. Bioremediasi Tanah Tercemar Limbah Minyak Berat Menggunakan Konsorsium Bakteri [Disertasi]. Insitut Pertanian Bogor. Bogor (ID). (in Indonesian).

Chithra S and SN Hema. 2014. Isolation and identification of oil degrading bacteria from oil contaminated soil and comparison of their bioremediation potential. GJRA 3: 181-184.

Clesceri RW, Greenberg AE, dan Eaton AD. 2005. Standard Methods for The Examination of Water and Wastewater, edition 20th. Washington (US): American Public Health Association Pr.

Dindar E, Þaðban FOT, Baºkaya HS. 2013. Bioremediation of petroleum-contaminated soil. J Biol Environ Sci 7: 39-47.

Elvina W, H Erliza and M yani. 2016. Formulasi dispersan minyak bumi dari surfaktan dietanolamida (DEA) dan metil ester sulfonat (MES). J Teknologi Industri Pertanian 26: 104-110. (in Indonesian).

Euan S, S Prashant, P Thavamani, K Ramadass, N Ravi and M Mallavarapu. 2015. Remediation trials for hydrocarbon-contaminated soils in arid environments: evaluation of bioslurry and biopiling techniques. Int Dech Monog 101: 56-65.

Eun-Hee L, YS Kang and KS Cho. 2011. Bioremediation of diesel-contaminated soils by natural attenuation, biostimulation and bioaugmentation employing Rhodococcus sp. EH831. Korean J Microbiol Biotechnol 39: 86-92.

Frutos FJG, RPO Escolano, A Rubio, A Gimeno, MD Fernandez, G Carbonell, C Perucha and J Laguna. 2012. Remediation trials for hydrocarbon-contaminated process: sludge from a soil washing Evaluation of bioremediation technologies. J Hazard Mat 200: 262-271.

ICARRD [Indonesian Center for Agricultural Resources Research and Development]. 2014. Soil National Taxonomy. Agricultural Research and Development Agency, Indonesian Ministry of Agriculture.

Kalbelitz N, J Machackova, G Imfeld, M Brennerova, DH Pieper, HJ Heipieper and H Junca. 2009. Enhancement of the Microbial Community Biomass and Diversity During Air Sparging Bioremediation of a Soil Highly Contaminated with Kerosene and BTEX. Appl Microb Biotechnol 82: 565-577.

Liado S, AM Solanas, J de Lapuente, M Borras and M Vinas. 2012. A diversiûed approach to evaluate biostimulation and bioaugmentation strategies for heavily-oil-contaminated soil. Sci Total Environ 435: 262-269.

Lidgren C, L Helene and F Jonas. 2001. Oil Spill Dispersant Risk Assessment for Swedish Waters. IVL Publication service. Stockholm

Liu PWG, TC Chang, LM Whang, CH Kao, PT Pan and SS Cheng. 2011. Bioremediation of petroleum hydrocarbon contaminated soil: Effects of strategies and microbial community shift. Dech Monog 65:1119-1127.

Margesin R and F Schinner. 2001. Bioremediation (natural attenuation and biostimulation) of diesel-oil-contaminated soil in an alpine glacier skiing area. Appl Env Microbiol 67: 3127-3133.

Militon C, D Boucher, C Bachelard, G Perchet, V Barra, J Troquet, E Peyretaillade and P Peyret. 2010. Bacterial community changes during bioremediation of aliphatic hydrocarbon-contaminated soil. FEMS Microbiol Ecol 74: 669-681.

Montgomery DC. 1997. Design and analysis of experiments, 4th edition. John Wiley & Sons. New York.

Nugroho A. 2007. Biodegradasi ‘sludge’ minyak bumi dalam skala mikrokosmos. Makara Teknologi 10: 82-89.

Nuning Vita H. 2009. Produksi biosurfaktan oleh Bacillus megaterium dan pengaruhnya terhadap biodegradasi polyaromatic hydrocarbons (PAHs) [Tesis]. Institut Pertanian Bogor. Bogor (ID). (in Indonesian).

Ros M, I Rodríguez, C García and MT Hernandez. 2014. Bacterial community in semiarid hydrocarbon contaminated soils treated by aeration and organic amendments. Int Biodeterior Biodegrad 94: 200-206.

Simarro R, LF Gonzaleza, N Bautistab and MC Molinaa. 2013. Assessment of the efûciency of in situ bioremediation techniques in a creosote polluted soil: change in bacterial community. J Hazard Mater 262: 158-167.

Soil Survey Staff. 2014. Kunci Taksonomi Tanah. Edisi Ketiga, 2015. Balai Besar Penelitian dan Sumberdaya Lahan Pertanian. Badan Penelitian dan Pengembangan Pertanian, Kementrian Pertanian. (in Indonesian).

Suardana P, M Mulyono, S Setyo, D Supardi and E Santoso. 2002. Pengaruh surfaktan alkilbenzena sulfonat linear dalam mempercepat bioremediasi limbah minyak bumi. Simposium Nasional-IATMI, Jakarta. (in Indonesian).

Syakti AD, M Yani, NV Hidayati, AS Siregar, P Doumenq and IM Sudiana. 2013. The bioremediation potential of hydrocarbonoclastic bacteria isolated from a mangrove contaminated by petroleum hydrocarbons on cilacap coast, Indonesia. J Bioremed 17:11-20.

Yaohui Xu and Lu Mang. 2010. Bioremediation of crude oil-contaminated soil: comparison of different biostimulation and bioaugmentation treatments. J Hazardous Materials 183: 395-401.

Zhang G, W Yue-ting, Q Xin-ping and M Qin. 2005. Biodegradation of crude oil by Pseudomonas aeruginosa in the presence of rhamnolipids. J Zhejiang University Science. 6B: 725-73.

DOI: http://dx.doi.org/10.5400/jts.2020.v25i1.1-10